Oil level check
Check the oil level as indicated every important manufacturers, if below the minimum level, to integrate.
Verify the proper operation of the pumps, gauges and manual activation of the solenoid valves.
From time to time verify the integrity of the electric contacts by spraying a protective agent against corrosion, due to sea salt.
It is advisable to verify anchorage bolts locking and a little joints greasing at each beginning and season end.
The procedure of air bleeding in the plants is not necessary because it is automatically performed by the control units gradually that the hydraulic oil circulates in the pipes.
CAUTIONAn improper use of the garage hatch and of the relevant safety closing system of the garage deck and of the gangway, the alteration of the valves’ setting values and/or the failure to comply with the handling procedures indicated in this manual, relieves CUSTOM LINE from any responsibility.
ENVIRONMENTDo not discharge hydraulic oil in the sea, but in the special areas for toxic waste disposal.
System failure
In case of electric system or electric current failure, it is possible to handle the gangway, the garage hatch and the garage deck by means of the emergency manual pump.
To make the handling operations with the manual pump proceed as follows for both the walkway garage control unit:
By shifting the plug on top of the different solenoid valves, it is possible to perform all operations manually.
Outer cleaning
To keep all our accessories and their parts in good working order, they should be cleaned carefully and thoroughly as often as possible.
The gangway, the garage hatch and the platform are in a very critical position with respect to all the on-board accessories, being in continuous contact with water, acid exhaust fumes, and therefore require more thorough cleaning.
For a careful and thorough clearing operation, cover all the steel parts with a layer of paraffin oil. As far as the coated parts are concerned, use a paste/cream.
This will prevent the forming of rust stains, that could give the impression the device is built with materials not suitable for its use.
CAUTIONDuring cleaning or maintenance operations, make sure that nobody can activate the gangway, garage deck and garage hatch, as this could cause heavy injury to the people working.
Cut off power supply.
CAUTIONThe check and maintenance operation must be carried out by skilled technicians, instructed about the operation of the garage deck, garage hatch and gangway.
DANGERRisk of electric shock from leakage currents. Never swim in waters near harbours or marinas.
CAUTIONPay attention to moving parts.
CAUTIONThe gangway, the garage hatch, and the hydraulic platform must always remain closed during navigation.
DANGERNever navigate with the gangway, garage hatch, and hydraulic platform incorrectly and not completely closed.
WARNINGAlways check the correct position of the garage hatch and gangway from the shore.
CAUTIONDo not use the gangway as a springboard.
CAUTIONPay attention to moving parts.
WARNINGUse and suggest to passengers comfortable shoes and eventually help them with the boarding.
WARNINGNever jump on the gangway.
CAUTIONPosition the gangway in such a way that it cannot touch the shore, either because of the normal yacht swinging or of the tide change. Should the gangway strike against the shore, it could get seriously damaged.
DANGERNever use the gangway to lift persons, even though the same is provided and tested to lift much heavier weights. Always make sure that the maximum load suggested by the Manufacturer is not exceeded. Never operate the gangway when someone is passing nearby. When walking on the gangway, be cautious and keep hold to the handrail; as it is made of rope, it cannot be considered a rigid and safe support, but simply a help to keep balance.
CAUTIONAlways pay the utmost attention to the movements of the gangway; in case of emergency, press any button of the remote control or of the panel to stop the gangway.
CAUTIONThe hydraulic gangway, even if easy manoeuvrable, might damage people and things. Its use is recommended only to well experienced people.
DANGERNever operate the gangway when someone is passing nearby.
When walking on the gangway, be cautious and keep hold to the handrail; as it is made of rope, it cannot be considered a rigid and safe support, but simply a help to keep balance.
At least once a week carry out the washing with fresh water and an accurate cleaning.
At least once a month:
CAUTIONCUSTOM LINE declines all responsibility for any accident to persons or damage to property caused by a wrong use of the on-board devices or systems.